Moto Morini Excalibur 501

Dutaceria · Post by **Dutaceria** » 12 Apr 2006 07:37

Do anyone want to share knowledge with me for this type of bike? I need some technical support and maybe some advise on location to purchase the parts. Send e-mail to me or just give me a call at 60195958844

http://i5.photobucket.com/albums/y152/d ... morini.jpg

Coxey · Post by **Coxey** » 28 Apr 2006 14:03

What on earth happened to this bike?!!!!

Dutaceria · Post by **Dutaceria** » 02 May 2006 10:16

This bike was kept in store for 7 years and was not even start the engine. The owner claims that the battery was always spoilt in a few month times.
Q.
1. Can I just place the battery and start the engine as usual? Will this spoilt the engine instantly?
2. Can anyone give me the correct way to make the engine alive back? Any spesified method?

Your help much apprieciated

Post by **SteveMRC** » 02 May 2006 19:27

Does your bike have a kickstarter?
Sounds a silly question to ask but I have only seen a couple of the factory customs and never taken too much notice of them.

After 7 years I would, at the very least, drain and replace the oil, put on a new cambelt, replace brake fluid and replace the battery and replace the petrol in the tank.
You may find that engine oil seals, brake lines and rubber parts in the brake system are all dried out and cracked, likewise the tyres.

Try to turn the engine over with the ignition off with the kickstarter or by putting it in gear and turning the back wheel to see if it has seized before trying to start with the button.

Not sure what the tropical climate in Malaysia would do to a bike in 7 years.

Steve

Dutaceria · Post by **Dutaceria** » 04 May 2006 03:16

Hi there,
Thank you for your kind advise. I will try the method and will let you know the result.

Hazli

hdbiker · Post by **hdbiker** » 11 May 2006 00:39

Hi Hazli!
Try the advice of Steven.If you want the part list of Excalibur just go here:
http://www.morinispecial.it/manuali/Man ... alibur.pdf
If you want the maintenance manual just send me your email.I hope that excalibur will work soon!Great bike!
Many regards from Greece,Vangelis

Dutaceria · Post by **Dutaceria** » 11 May 2006 01:05

Hi there,
Thanks you for the intention. If anyone willing to give a hand, here is my e-mail: duta_ceria@time.net.my

Hazli

MRC Forum- brought to you by www.morini-riders-club.com

Moto Morini Excalibur 501

Moto Morini Excalibur 501

Good grief