Clutch pushrod

Camel, Sahara, Kanguro, Coguaro

Clutch pushrod

Postby 3potjohn » 15 Oct 2020 17:51

Investigating a slight weep of oil on this Coguaro around the right engine side. Not the crank seal. I replaced the gear selector oil seal a few weeks ago.The oil may be coming out via the pushrod seal, then running down over the neutral switch and back and under the rear cases, I removed the clutch arm and pulled out the short pushrod ( approx 29.8mm long by 6.96 mm diameter on this one) and the small oil seal ( 14 mm od 4 mm thick ?7mm I’d) The ends of the pushrod are not bad but along its length is somewhat scored and chewed. Do not know how or why? Seems a bit odd though.Wonder about the inner bore.
Can anyone confirm this short rod size or part number. I will try and source a replacement and seal.
If it’s not one thing it’s another.....
John
3potjohn
 
Posts: 782
Joined: 02 Jun 2007 13:58
Location: Devon

Re: Clutch pushrod

Postby 'It must be a .....' » 15 Oct 2020 18:04

HI,
500 & 501 engines

Clutch operating (release) rod is 30mm long and a diameter of 7mm
Two clutch release rods both 89mm long with a diameter of just under 5mm
Clutch operating 'mushroom' 50mm long and again with a diameter of just under 5mm and the head diameter is 16.25

Trust this helps, Ian
'It must be a .....'
 
Posts: 261
Joined: 12 Sep 2010 12:25

Re: Clutch pushrod

Postby 3potjohn » 15 Oct 2020 20:51

Thanks for this.Very helpful.
John
3potjohn
 
Posts: 782
Joined: 02 Jun 2007 13:58
Location: Devon

Re: Clutch pushrod

Postby 3potjohn » 22 Oct 2020 15:36

Complete clutch operating mechanism arrived today wrapped in Bezirksblätter Tirol.Clutch arm dimple barely worn.Swapped the lot.If it had not been for the postage it would have been VERY cheap.Still a good result.
John
3potjohn
 
Posts: 782
Joined: 02 Jun 2007 13:58
Location: Devon

Re: Clutch pushrod

Postby mbmm350s » 22 Oct 2020 18:25

Bezirksblätter Tirol

Hey John is that a kind of cheese? I did find a pushrod but it looked like it had been nibbled by mice.
Mark
mbmm350s
 
Posts: 341
Joined: 22 Jun 2018 10:18
Location: Berkshire UK

Re: Clutch pushrod

Postby 3potjohn » 22 Oct 2020 22:03

No mice here, just an Austrian newspaper. And as I write the cat just deliver a mouse.I’ll give it the paper to read.
John
3potjohn
 
Posts: 782
Joined: 02 Jun 2007 13:58
Location: Devon


Return to Off road bikes

Who is online

Users browsing this forum: No registered users and 2 guests