MRC Forum- brought to you by www.morini-riders-club.com

Sounds reasonable. I changed as I was having problems and decided the stator need a rewind. Looking at the cost (if I could find anybody to do it anyway) I thought I might as well buy a new system as usually with the Law of Sod once one things breaks other components will follow. Anyway, if I am hap...

Some great information , one thing to consider is to fit a relay to negate the old wiring and use the old coil wire to trigger the relay then you will get the full 12V feed coil_diagram.jpg This is my next project after I have road tested the bike. I only have 0.1 volts drop from battery to coils a...

I've just fitted an SWF ignition on my 250 2C and I'm beyond happy with it! Easy to fit, easy to adjust and the bike is transformed, pulling much better throughout the rev range. All the original wiring is still on the bike, if I wanted to go back, but I can't think of any reason I would. The kit c...

Rick, I have just installed an SWF system on a Strada. I managed to wire the +12 volts via the kill switch, using the original wiring in case I decide to fit the original system. It is a simple kit. A bit of a fiddle to fit the rotor, but easy to set the timing. Once fitted, the bike started on firs...

Fuel remaining at reserve is not a good indicator of range. How much can be used? The tank may not run dry before the fuel stops flowing. Also, do you really want to drain the bottom of the tank, it is probably full of crud which will block the filters on the taps and the carbs and some will find it...

Lewes96 wrote: ↑07 Apr 2024 22:46 Headlight bulb is 35watts

Do you run with it on all the time?

scbond2@yahoo.co.uk wrote: ↑07 Apr 2024 19:06 Ill remember to tell the fuzz that

Luckily I did not post in Scotland so no hate crime against Morinis has been committed!

What is the wattage of the headlight? The alternator chucks out about 140W at high revs. Brake light and two indicators are +/- 60 Watts. Add in your headlight and tail light and what is left has to charge the battery. Run at slower speeds, the output drops. My BMW has a voltage of 14volts with no l...

The technique:

Ignition on
Fuel on
Chokes up and
Press button. Electric kick-start is best.

Perfect.

How satisfying finding a fault that only cost time!

If you read the blue book there is a section on fault finding the charging circuit. I would say that 12.5 volts across the battery at 5k rpm is a bit low. Your regulator may be faulty.

You may want to check the earthing points, too.

Thank you, Norbert.

This is good info.

A Sport piston with a Strada cam is a good option.

I know the 501 nikisil barrels do not fit an500 crankcase, but do the 350 nikisil barrels fit an earlier 350 crankcase?

Sport cam was used from the first sports up until the later K series bikes where they moved to the M cam. There should be an S Stamped in the cam between the middle lobes, not so helpful if the engine is together, but easy to check what cam you have by measuring with a timing disc. None of the Mori...

I would not think Morini could afford a different casing.

Has the linkage been changed, do you have rear sets?

Of course, I could be wrong, not unknown!